首先的弄清楚的是，發電機組的易損件中包含空氣濾清器、機油濾清器和柴油濾清器這三種濾清器，要延長柴油發電機組的使用壽命，在使用過程中，就要加強空氣濾清器、機油濾清器和柴油濾清器這三濾的保養，充分發揮它們的作用。

　　The first thing to understand is that the vulnerable parts of the generator set include three types of filters: air filter, oil filter, and diesel filter. To extend the service life of the diesel generator set, it is necessary to strengthen the maintenance of the air filter, oil filter, and diesel filter during use, and fully utilize their functions.

　　空氣濾清器在安裝時不可漏裝、反裝或錯裝各密封墊圈及橡膠連接管，并保證各按嵌處的嚴密性。使用的紙質集塵杯空氣濾清器，每工作50-100小時，要清除塵土1次，可用軟毛刷將表面塵土刷掉，若工作時間超過500小時或已損壞，就應及時更換。使用油浴式空氣濾清器，每工作100-200小時，應用清潔的柴油清洗濾芯，并更換其中的機油，若濾芯已破碎，就需立即更換，并注意在使用中，按規定添加機油。

　　When installing the air filter, it is not allowed to miss, reverse or incorrectly install the sealing gaskets and rubber connecting pipes, and ensure the tightness of each fitting. The paper dust collection cup air filter used should be cleaned of dust once every 50-100 hours of operation. The surface dust can be brushed off with a soft bristled brush. If it has been in operation for more than 500 hours or is damaged, it should be replaced in a timely manner. Using an oil bath air filter, clean the filter element with clean diesel every 100-200 hours of operation and replace the engine oil. If the filter element is broken, it should be replaced immediately, and attention should be paid to adding engine oil according to regulations during use.

　　機油濾清器在柴油發電機組使用中如不及時保養，濾芯堵塞、機油壓力增加，安全閥打開，潤滑油直接流入主油道，會加劇潤滑表面的磨損，影響柴油發電機組的使用壽命。因此，機油濾清器每工作180-200小時，就要清洗1次，發現破損，應立即更換，以防止雜質進入潤滑表面。

　　If the oil filter is not maintained in a timely manner during the use of the diesel generator set, the filter element will become clogged, the oil pressure will increase, the safety valve will open, and the lubricating oil will directly flow into the main oil passage, which will aggravate the wear of the lubricating surface and affect the service life of the diesel generator set. Therefore, the oil filter should be cleaned once every 180-200 hours of operation. If any damage is found, it should be replaced immediately to prevent impurities from entering the lubricating surface.

　　發電機組換季使用，還應清洗曲軸箱和各潤滑表面，方法是用機油、煤油和柴油混合后作洗滌油，可在機油放出后加入洗滌油清洗，然后，柴油發電機組低速運轉3-5分鐘，再放盡洗滌油，加入新機油。

　　When using the generator set during seasonal changes, the crankcase and lubrication surfaces should also be cleaned. The method is to mix engine oil, kerosene, and diesel to make a washing oil. After the engine oil is released, the washing oil can be added for cleaning. Then, the diesel generator set should be run at low speed for 3-5 minutes, and the washing oil should be drained before adding new engine oil.

　　燃油供給系統中的各種燃油濾清器，每工作100-200小時，就應清除雜物1次，并對油箱和各輸油管道進行清洗。在清洗濾芯和密封件時，應特別仔細，發現破損，需及時更換。在季節過渡換油時，應對整個燃油供給系統的各零部件進行清洗。使用的柴油，應符合季節要求，并需經48小時的沉淀凈化處理。

　　Various fuel filters in the fuel supply system should be cleaned of debris every 100-200 hours of operation, and the fuel tank and various fuel pipelines should be cleaned. When cleaning the filter element and seals, special attention should be paid. If any damage is found, it should be replaced in a timely manner. When changing oil during seasonal transitions, all components of the entire fuel supply system should be cleaned. The diesel used should meet the seasonal requirements and undergo 48 hours of precipitation purification treatment.

　　本文來自：發電機組更多精彩內容請點擊我們的網站：http://m.shgcmy.com我們將傾情為您解答。

　　This article is from: Generator Sets. For more exciting content, please click on our website: http://m.shgcmy.com We will wholeheartedly provide you with answers.